Read Ebook: Practical Rules for the Management of a Locomotive Engine in the Station on the Road and in cases of Accident by Gregory Charles Hutton

Font size: 10 px 15 px 20 px 25 px 30 px 35 px

Background color: BlackWhiteGrayLight GrayDark GrayDim Gray

Text color: BlackWhiteGrayLight GrayDark GrayDim Gray

Apply/Save settings

Ebook has 40 lines and 10235 words, and 1 pages

f the water as high as possible.

It is observed that when any variation takes place in the pressure of the steam, a corresponding change occurs in the level of the water,--that when the pressure of the steam rises or falls, the height of the water rises or falls simultaneously. Partly for this reason, and partly to allow the more rapid generation of steam, the feed-pumps are not generally allowed to act when the Engine starts: a knowledge of this fact also shows the necessity of the water being above the ordinary level, before a decrease is allowed in the pressure of the steam.

When the Engine is highest on an inclined plane, rather a greater height of water must be kept over the fire-box than on a level, in order that the chimney ends of the tubes may be well covered.

The most favourable time for allowing the feed-pumps to act, is when the steam is blowing off with force from the safety-valve, and the fire strong; and the least favourable time is when the steam and fire are low: indeed the Engine-man should manage that it may never be necessary in the latter case, as the addition of water rapidly lowers the steam.

In order to know the force of the steam, one hand may occasionally lift or depress for a moment the lever of the safety-valve, according as the steam is under or over the working pressure; and a little practice will soon enable a person to judge the extent of excess or deficiency.

Both feed-pumps should not commence working at the same time.

The water should never be allowed to run low before arriving at any part of the road where considerable power is required, as steam is produced more rapidly when both pumps are turned off,--a measure which is imprudent unless the water is high.

When "the feed" is turned on, the Engine-man should try the pet-cock to see whether the pump is acting freely: the water thrown from it should be in forcible intermittent jets; warm water with a little steam will frequently escape from it at first; if this should continue, it may be concluded that the upper clack does not act; and if the water is in a continuous stream without pulsations, the lower clack is out of order. In either case it will not be prudent to trust too much to the faulty pump, but the evil may frequently be remedied by working the pump a short time with the pet-cock open, or alternately turned on and off.

Coke is put on the fire by the Stoker, at the order of the Engine-man, who should hold the chain of the fire-door in his hand, and open it for as short a time as possible, while the Stoker throws on each shovelful of coke: the shovel should be well filled, and the coke distributed equally over the fire.

In most Engines, the fuel need not be higher than the bottom of the fire-door; and if allowed to fall more than 6 or 8 inches below it, it must not be expected that the pressure of the steam will be maintained, if the Engine has a load.

In other circumstances, provided the fire is low enough to require fuel, the best time to put on coke is when the water is sufficiently high to turn off the feed-pumps, the steam slightly blowing off, and the Engine travelling at a good speed.

No definite instructions can be given for the frequency with which coke must be laid on the fire, as it varies according to the duty to be done, and the water consequently to be evaporated: in cases of heavy duty and bad gradients, it may at times be necessary even at as short an interval as 2 miles; under contrary circumstances an Engine may sometimes run as much as 15 miles without adding fresh coke.

The fire should be allowed to run rather low before arriving at the top of an inclined plane down which the steam will not be used: on beginning to descend the plane, fuel should be put on the fire, which will burn up by the time the train reaches the bottom of the plane.

If it is wished to keep up the steam, it is better not to supply water and fuel at the same time.

While running, the Stoker should occasionally pick the ashes from the tubes to clear the draught.

If there should be, at any time, an unnecessary quantity and force of steam, it is readily reduced by opening the fire-door, and by turning on the feed-pumps; if there should be too little, the Engine-man must be content to run slowly for a short time, keep the regulator only partially open, and put on a gradual supply of coke.

When the water in the boiler is high, many Engines begin to prime, especially after running for several days. When this occurs, the aperture of the regulator should be diminished, and the fire-door and the discharge cocks of the cylinders opened: if the height of the water will allow it, the blow-off cock of the boiler may be opened for a short time to carry off the sediment, which will be found advantageous.

The Engine-man should frequently look to the working gear, to see that it is in proper order, and to rectify any deficiency at the next Station.

On nearing a Station where it is intended to stop, the regulator should be gradually eased off at about five-eighths of a mile from the Station, so that the train may be more under control, and when from a quarter to half a mile distant, according to the velocity and weight of the train, the steam should be completely shut off, and the train brought to rest by the breaks. In approaching terminal Stations the steam should be shut off at a greater distance than at the intermediate Stations, to prevent the possibility of overrunning the mark from the failure of breaks. It must be borne in mind that the breaks act much less efficiently in wet or frosty weather, when it becomes necessary to shut off the steam further from the Stations. The use of the reversing-lever ought, as much as possible, to be avoided: it may sometimes be placed in the middle position , but it should never be completely reversed unless absolutely necessary for the stoppage of the train.

At the intermediate Stations, the Stoker should frequently oil all the bearings not supplied by the large oil-vessels, and fill the oil-cups of the connecting-rods, slides, &c., and if any of the bearings, brasses, &c., are hot, they should be more copiously oiled, and eased if necessary. He should also examine all the working gear cursorily to see if it is in a complete state; particular attention should be given to the axle-bearings, and especially those of the cranked axle, which sometimes become so hot by running as to require cooling by throwing on water.

In case of the driving wheels slipping much in starting from a Station, the opening of the regulator should be reduced, and only gradually opened as the wheel bites; the Stoker is sometimes obliged to scatter ashes, sand, &c., before the wheels: some Engines are now furnished with hoppers in front, opened by a handle from the foot-board, by means of which sand may be dropped on the rails in front of the driving wheels.

If slipping is observed to an unusual extent, it may be inferred that there is not sufficient weight on the driving wheels, and the springs ought to be tightened by screwing up the nuts of the bearing bolts: or where the framing is hung to the springs by plain links, the spring pins must be lengthened the next time the Engine is in the repairing shops. A deficiency of weight on the front or hind wheels is indicated by the pitching of the Engine, and should be remedied in a similar manner.

The regulator should be gradually and completely closed, when the Engine or train pitches or rocks violently,--in passing a series of points and crossings,--in very sharp curves, especially if double,--in rough parts of the permanent way,--and in descending planes whose inclination is sufficient to carry the train down, without steam, at a velocity of 30 miles per hour. In descending such an inclined plane, if it should be found that the velocity is greater than 30 miles per hour, it should be reduced by gently applying the break.

On every Railway there is a prescribed limit to the pressure of the steam, and no circumstance should induce the Engine-man to use steam at a higher pressure, or in any case to weight the lever, or hold it down for more than a moment. When there are two safety-valves, that which is out of reach may be set at the limit of pressure, and the valve next the foot-board some pounds lower. It is an advantage to have a stop placed below the lever of the safety-valve on the screw of the spring balance, to prevent its being inadvertently screwed down to more than the working pressure.

The steam whistle is obviously intended to give notice of danger: on this account its use is forbidden on some Railways, excepting on occasions of extreme emergency; but the variety of modulation of which it is susceptible has in others induced its adoption as a frequent warning. When the latter is the case, it has been found a safe measure to sound the whistle directly the steam has been shut off previously to stopping at a Station, and to give two short whistles the moment before starting, to warn parties of the approach and departure of the train. When this system is practised, the Engine-man should not turn on the full power of the whistle, but reserve it exclusively for cases of danger.

When near the end of the trip very little fire is wanted, and both feed-pumps should be turned on for a short distance before arriving at the Station, unless the Engine is to start again immediately. If it is intended to remain at the Station about an hour, the water should be considerably above the middle cock , which will be effected by keeping on both feed-pumps from a half to three-quarters of a mile. The safety-valve should, at the same time, be eased off to 35 lbs.

If the train is brought into the Station by a tow-rope, great care must be taken to stretch the rope gradually by a gentle advance of the Engine, which must be stopped at a signal from the tow-rope man.

It would be prudent to conduct the examination described at the commencement, directly the Engine arrives at the Station, in order to leave time for any repair which may be required.

When an Engine is running the last trip for the day, no fuel need be put on for the last 10, 15, or 20 miles, according as the duty is heavy or light; indeed, the fire may be nearly run out by the time the Engine stops, if the gradients, &c., are favourable. For a considerable distance before stopping both pumps should be at work, so that the water in the boiler may be at or above the top cock when the Engine stops, and the safety-valve should be eased off to 25 lbs. per square inch.

On stopping over the pit, the fire is drawn by opening the fire-door, introducing the arrow-headed poker through the fire-bars, and pulling up two or three of them from the bottom of the furnace, by which room will be allowed for the rest to be separated, and the fire fall through into the ash-pan, from which it is raked out by the Stoker. The practice of blowing off all the water from a boiler by the pressure of the steam should never be allowed, without an express order from the Superintendent of Locomotives, when the boiler is unusually full of mud; as, if frequently practised, it will seriously injure the fire-box and tubes.

THE MANAGEMENT OF A LOCOMOTIVE ENGINE IN CASES OF ACCIDENT.

An Engine is liable to several accidents while running, and it is important that the Engine-man should know how to act promptly under the circumstances. In the following list several cases are enumerated, with the particular steps to be taken in each.

The bursting of a tube or other causes will sometimes lead to the lagging or casing of the boiler catching fire, which should be extinguished by throwing on water from the Tender-cistern in a fire-bucket, or from the water crane at a Station.

If it should be found impracticable to move the train, the Engine might run on alone for assistance; but in any case where the Engine is obliged to remain stationary, the fire must be drawn directly the water is down to the bottom cock.

The Engine should first be separated from the Tender, which, being a lighter weight, may be pushed out of the way, and leave more room for operating on the Engine; this, if it has fallen over on its side, should be lifted as quickly as may be into a vertical position; to do so, a purchase should be obtained under the framing on the lowest side, in two places if possible; two long and tough sways should be brought to bear on these points, and several men placed to weigh upon each; and as the Engine is gradually lifted by the sways, every movement should be followed up and supported by screw-jacks bedded on timber blocking. When the Engine has been lifted upright, it should be firmly supported by timbers placed as stanchions under the framing; the earth may then be cautiously removed from under the wheels, and a length of rail introduced, taking care to bed it as securely as possible on the blockings previously laid down, without disturbing them: the same process should be repeated on the other side, and cross sleepers driven in under both rails to secure the foundation. As soon as the Engine is in a vertical position and rails inserted under the wheels, a temporary railway may be laid down in continuation, and the Engine again drawn on the main line. It will much facilitate the raising of the Engine if the water is drawn away out of the boiler as soon as it is sufficiently cool.

In all cases of accident involving stoppage on the main line, it is of the highest importance that some person should immediately be sent back about three-quarters of a mile along the road, to give the proper signal of obstruction, and prevent any following train from running in unexpectedly.

The most essential personal qualifications of an Engine-man are, sobriety and steadiness, activity, presence of mind, and unceasing watchfulness; and wherever these are combined with an accurate knowledge of the construction of a Locomotive Engine and the principles of its management, they tend in no small degree towards rendering Railways, what they properly are, the safest as well as the most agreeable mode of travelling.

REGULATIONS FOR THE FIRST APPOINTMENT OF AN ENGINE-MAN, ADOPTED BY THE DIRECTORS OF THE LONDON AND CROYDON RAILWAY.

A TABLE OF VELOCITIES.

Time occupied in Time occupied in Velocity Travelling one eight Travelling quarter of of a mile a mile 7.5 15 60.0 8 16 56.2 8.5 17 52.9 9 18 50.0 9.5 19 47.4 10 20 45.0 10.5 21 42.9 11 22 40.9 11.5 23 39.1 12 24 37.5 12.5 25 36.0 13 26 34.6 13.5 27 33.3 14 28 32.1 14.5 29 31.0 15 30 30.0 15.5 31 29.0 16 32 28.1 16.5 33 27.3 17 34 26.5 17.5 35 25.7 18 36 25.0 18.5 37 24.3 19 38 23.7 19.5 39 23.1 20 40 22.5 20.5 41 21.9 21 42 21.4 21.5 43 20.9 22 44 20.4 22.5 45 20.0 23 46 19.6 23.5 47 19.1 24 48 18.7 24.5 49 18.4 25 50 18.0 25.5 51 17.7 26 52 17.3 26.5 53 17.0 27 54 16.7 28 56 16.0 29 58 15.5 30 60 15.0 31 62 14.5 32 64 14.1 33 66 13.6 34 68 13.2 35 70 12.8 36 72 12.5 37 74 12.2 38 76 11.8 39 78 11.5 40 80 11.25 41 82 11.0 42 84 10.7 43 86 10.5 44 88 10.2 45 90 10.0

Share on: WhatsApp @Hash Facebook Tweet